Mortezapour, H., Rashedi, S. J., Akhavan, H. R., Maghsoudi, H. (2017). Experimental Analysis of a Solar Dryer Equipped with a Novel Heat Recovery System for Onion Drying. , 19(6), 1227-1240.
H. Mortezapour; S. J. Rashedi; H. R. Akhavan; H. Maghsoudi. "Experimental Analysis of a Solar Dryer Equipped with a Novel Heat Recovery System for Onion Drying". , 19, 6, 2017, 1227-1240.
Mortezapour, H., Rashedi, S. J., Akhavan, H. R., Maghsoudi, H. (2017). 'Experimental Analysis of a Solar Dryer Equipped with a Novel Heat Recovery System for Onion Drying', , 19(6), pp. 1227-1240.
Mortezapour, H., Rashedi, S. J., Akhavan, H. R., Maghsoudi, H. Experimental Analysis of a Solar Dryer Equipped with a Novel Heat Recovery System for Onion Drying. , 2017; 19(6): 1227-1240.

Experimental Analysis of a Solar Dryer Equipped with a Novel Heat Recovery System for Onion Drying

Journal of Agricultural Science and Technology
Article 2, Volume 19, Issue 6, 2017, Pages 1227-1240    PDF (833.55 K)
Authors
H. Mortezapour* 1; S. J. Rashedi1; H. R. Akhavan2; H. Maghsoudi1
1Department of Mechanical Engineering of Bio-systems, Faculty of Agriculture, Shahid Bahonar University of Kerman, Kerman, Islamic Republic of Iran.
2Department of Food Science and Technology, Faculty of Agriculture, Shahid Bahonar University of Kerman, Kerman, Islamic Republic of Iran.
Abstract
In hot air dryers, only a small percentage of the provided thermal energy is used for the drying process, while a large fraction is lost via the exhaust air. To recycle waste heat from the exhaust air, the present study aimed to develop a solar dryer equipped with a novel heat recovery system. The designed dryer comprised of a solar air collector, a drying chamber, an internal closed-loop air circuit and an open-duct heat recovery system. The evaluation tests were conducted at different allowable relative humidities (RH) and mass flow rates of the recirculating air. The results indicated that the best solar fraction was at the highest RH and air flow rate. Increasing the RH from 7 to 17% caused a reduction of 51% in electricity consumption. Furthermore, electrical energy needed for drying increased by 24% with raising the air flow rate from 0.008 to 0.016 kg s-1. A minimum specific energy consumption of 7.54 MJ kg-1 was observed at the highest RH and the lowest air flow rate. At a constant RH, reduction of the air flow rate led to an increasing trend in lightness and decreasing trends in browning index of the products. Moreover, increasing the RH from 7 to 17% increased lightness and decreased browning index. In general, it can be stated that the best colour quality was achieved when the minimum air flow rate and the maximum RH were used for the solar drying.
Keywords
Browning index; Energy recycling; Specific energy consumption; Surface colour
References
Statistics
Article View: 121
PDF Download: 84
Statistics
Number of Journals45
Number of Issues2,160
Number of Articles24,572
Article View19,861,791
PDF Download16,045,096